ENSILAGE

This article appears in Volume V09, Page 654 of the Encyclopedia Britannica.

Encyclopedia Britannica - Main :: EMS-EUD

ENSILAGE , the process of preserving green food for cattle in an undried condition in a silo (from Gr. aipos, Lat. sirus, a pit for holding grain), i.e. a pit, an erection above ground, or stack, from which air has been as far as possible excluded. The

fodder

FODDER

which is the result of the process is called silage. In various parts of Germany a method of preserving green

fodder

FODDER

precisely similar to that used in the case of Sauerkraut has prevailed for upwards of a century.

Special

SPECIAL

attention was first directed to the practice of ensilage by a French agriculturist, Auguste Goffart of the district of Sologne, near Orleans, who in 1877 published a work (Manuel de la culture et de l'ensilage des mars et autres fourrages verts) detailing the experiences of many years in preserving green crops in silos. An English translation of Goffart's book by J. B. Brown was published in New

York

in 1879, and, as various experiments had been previously made in the United States in the way of preserving green crops in pits, Goffart's experience attracted considerable attention. The conditions of American dairy farming proved eminently suitable for the ensiling of green maize fodder; and the success of the method was soon indisputably demonstrated among the New England farmers. The favourable results obtained in America led to much discussion and to the introduction of the system in the United Kingdom, where, with different conditions, success has been more qualified.
It has been abundantly proved that ensilage forms a wholesome and nutritious food for Cattle. It can be substituted for root crops with advantage, because it is succulent and digestible; milk resulting from it is good in quality and taste; it can be secured largely irrespective of weather; it carries over grass from the period of great abundance and waste to times when none would otherwise be available; and a larger number of cattle can be supported on a given area by the use of ensilage than is possible by the use of green crops.
Early silos were made of stone or concrete either above or below ground, but it is recognized that air may be sufficiently excluded in a tightly pressed stack, though in this case a few inches of the fodder round the sides is generally useless owing to mildew. In America round erections made of

wood

and 35 or 40 ft. in depth are most commonly used. The crops suitable for ensilage are the

ordinary

ORDINARY (med. Lat. ordinarius, Fr. ordinaire)

grasses

GRASSES

, clovers, lucerne, vetches, 'oats, rye and maize, the latter being the most important silage crop in America; various weeds may also be stored in silos with good results, notably spurrey (Spergula arvensis). a most troublesome plant in poor light soils. As a rule the crop should be mown
654
when in full flower, and deposited in the silo on the day of its cutting. Maize is cut a few days before it is ripe and is shredded before being elevated into the silo. Fair, dry weather is not essential; but it is found that when moisture, natural and extraneous, exceeds 75% of the whole, good results are not obtained. The material is spread in uniform layers over the floor of the silo, and closely packed and trodden down. If possible, not more than a foot or two should be added daily, so as to allow the mass to settle down closely, and to heat uniformly throughout. When the silo is filled or the stack built, a layer of straw or some other dry porous substance may be spread over the surface. In the silo the pressure of the material, when chaffed, excludes air from all but the top layer; in the case of the stack extra pressure is applied by means of planks or other weighty objects in order to prevent excessive heating.
The closeness with which the fodder is packed determines the nature of the resulting silage by regulating the chemical changes which occur in the stack. When closely packed, the

supply

SUPPLY (through Fr. from Lat. supplere, to fill up)

of oxygen is limited; and the attendant acid fermentation brings about the decomposition of the carbohydrates present into acetic, butyric and lactic acids. This product is named "sour silage." If, on the other hand, the fodder be unchaffed and loosely packed, or the silo be built gradually, oxidation proceeds more rapidly and the temperature rises; if the mass be compressed when the temperature is 14o16o F., the action ceases and " sweet silage results. The nitrogenous ingredients of the fodder also suffer change: in making sour silage as much as one-third of the albuminoids may be converted into amino and ammonium compounds; while in making " sweet silage " a less proportion is changed, but they become less digestible. In extreme cases, sour silage acquires a most disagreeable odour. On the other hand it keeps better than sweet silage when removed from the silo.

End of Article: ENSILAGE

If you wish, you can link directly to this article.

<a href="http://jcsm.org/StudyCenter/Encyclopedia/EMS_EUD/ENSILAGE.html">
ENSILAGE
</a>

(Previous)
ENSIGN (through the Fr. enseigne from the Latin...

(Next)
ENSTATITE

JCSM was founded in 1997 and exists to help the community and bring people into a life-changing and productive relationship with Jesus Christ. JCSM offers over 200,000 free web pages, including its weekly inspirational emails that were sent continuously for over a decade.

Jesus Christ Saves Ministries
P.O. Box 9297
San Diego, CA 92169
1-888-887-0417 or Email